[Closed] Guess the damage - VAG TDI Cambelt

You might have been right till Mr aa man brought his experience to the table and banjod it

You might have been right till Mr aa man brought his experience to the table and banjod it

One would assume that the AA will be assuming liability then?

And the answer is...

Cause:
Tensioner stud pulled out of engine block (probably due to 3rd or 4th timing belt going on the car (216,000miles)

Damage:
Garage said engine seems fine, start,runs and revs well. Compression good, no smoke etc.

Resolution:
Helicoil engine block for to fit new tensioner stud.
New timing belt and tensioner

Cost:
Missing NYD blast around local loop.

Losing Maxle on my Lyrics in the transfer of bike between various cars during the recovery process.

Win!

*thumb*

Name and fame the garage? That's decent service I reckon. Unless they actually screwed it up and are making nice - but even so, that's not bad.

stumpy01 - Member

He called the AA out to recover the car & the first thing the bloke said was to turn it over so he could see what's up - even after my mate told him it occurred while being driven back from having the cambelt changed. Nuts.

Really, what are the odds that the car had a belt issue while driving and was completely unscathed- and then turning it over for the AA man killed it?

Damage:
Garage said engine seems fine, start,runs and revs well. Compression good, no smoke etc.

Oh yes, I bet they did 😉

Really, what are the odds that the car had a belt issue while driving and was completely unscathed- and then turning it over for the AA man killed it?

Really, what are the odds that the car had a belt issue while driving and was completely unscathed- and then turning it over for the AA man killed it?

Well, it could have been held in some precarious position then when the engine stopped it became dislodged further, or another tooth slipped or something. Plausible, if not especially likely is my uninformed guess. But sounds like the OP got away with it.

Excellent luck there OP.
Buy a lottery ticket.

I didn't understand the "cost" resolution .. what's NYD ?

And sadly not bendyovertakeitupthebottomwithoutlube resolution we were all betting on.

Is dissapoint.

Same outcome as my colleague's A6. His has been fine since, the tensioner fail doesn't seem to banjax the engine every time.

lotto tickets ahoy.

good outcome.

NYD = New Year Day.

I think the fact it was still running when I turned it off probably saved the engine. The belt looked like it was about to fall off the top cam gear thing when the AA man undid the belt cover, so I think I was seconds away from total disaster...

had a similar thing happen on my last car...a nissan almera. driving home on the motorway...i heard a large crack and bang as something came off at 70mph. managed to drive the remaining 6 miles home tentatively. phoned Green Flag who sent an independent recovery guy to the house. luckily he didnt ask me to start the engine straight away. he had a look under the bonnet and told me that the belts had come off but that was due to the main pulley wheel shearing off its mounting plate. he did start the engine after that to check it was running fine. towed to the garage to get it replaced and all was good again.

the fact it was still running when I turned it off probably saved the engine

Eh, surely an engine has to be running for you to be able to turn it off?

Ticket bought... not that lucky it would seem.

Used up all your 2017 luck 😉

[quote=mikeyd ]I think the fact it was still running when I turned it off probably saved the engine.

So it could have been killed by turning it over on AA man's advice? Good outcome though 😀

[img] [/img]

The garage also dodged a bullet there.

It was completely out of their control and nothing to do with the work they did.

Most would have them strung up if the outcome was worse and they refused repair.

This is what all the fuss was about
[img] [/img]

And a bottle of Wainright to boot. Lovely beer